80 series manual gearbox oil

 · Re: Gearbox flush 80 series Landcruiser. I had a sticky 2nd gear in a manual Hiace about 15 years ago. It was worst when the gearbox was cold. Two things cured the problem. I drained whatever oil it had (which of course was unknown as it came with it). I used 75W90, which memory says is a Mobil multigrade gearbox product. Original oil: Land Cruiser 80 D: Transmission, automatic: 6 L: Check km/ 12 months, Change km/ 48 months: Original oil: Land Cruiser 80 TD: Transferbox: 1,3 L: Check km/ 12 months, Change km/ 48 months: 75W Land Cruiser 80 TD: Transmission, manual: 2,6 L: Check km/ 12 months, Change km/  · Oct 3, #7. Tim Whiting said: Hullo Everyone, I have a 80 series that has been "difficult " to change down from 3rd to 2nd for a while. Last week I had the gearbox, transfer case and clutch reconditioned. So excited when I picked the car up, only to be let down hard, 3rd to 2nd was pretty much exactly the same.

SynPower 75w90 Gear Oil: Valvoline SynPower Full Synthetic Gear Oil Manual Transmission on all vehicles equipped with a N52 engine: 5-series (E60) from production 3-series (E90/91) from 3/ production 3-series (E92/93) from 7/ production X3-series (E83) from 9/ production 1-Series coupe (E82) from 3/ production. Remove the drain plug on the bottom. Let it drain and reinstall the plug. Remove the filler plug on the side (looks just like the drain plug but higher up) Grab a couple quarts of Mobile 1 gear oil. Squirt it in the filler plug hole until it comes out. Reinstall the filler plug. Last edited: May 3, As far as i know the EP additive content is too high for yellow metals found in a old gearbox. I played it safe on my 80 and use a fully synthetic oil that states safe for use with phosphor bronze etc. The issue recently reared its head again with another vehicle. The handbook states 80/90 gear oil for the trans, then specifies 80/90 hypoid.

in this we went through the steps on how to change the oil in a manual transmission gearbox for ep82/ bolts -entry/ top bolt - size 17 x1leveler/ middle b. Lucas oil stabilizer in manual transmission. You can mix Lucas Oil Stabilizer 25% / 75% in a manual gearbox and 50% / 50% in the differential. Lucas Oil Stabilizer can be mixed with any petroleum-based or synthetic oil and is formulated for petrol or diesel engines. Is it time to change your 4x4's gearbox oil? Shaun Whale from 4WD Action shows us www.doorway.ru you'll need to do a gearbox oil change is a car jack, jack stands o.